capital and operating cost of sponge iron india

  • INDIA: Angry Villagers Bear Pollution Costs of Sponge …

    INDIA: Angry Villagers Bear Pollution Costs of Sponge …

    India is the world''s largest producer of sponge iron — which is extracted from iron ore and is used in making steel. The country produced an all-time high of 20 million tonnes in 2008-09, compared to just one million tonne in 1988 due to the quantum jump in demand for steel for …

    Get price
  • cost of sponge iron plant in india

    cost of sponge iron plant in india

    The sponge iron plants in India are located near the source of raw materials. ... plant safety measures, project cost and cost of pollution control measures Rotary Kiln Process of Making Sponge Iron Fig. 2.5 Material balance in a rotary kiln sponge iron plant ... gas and conversion cost at similar capacities ...

    Get price
  • Sponge iron industry needs quick actions for survival

    Sponge iron industry needs quick actions for survival

     · Limited availability of coking coal in India and abroad will encourage steel production in the country through combination of sponge iron and blast furnace, e.g sponge iron-BF-EAF route. There is tremendous scope for setting up of rotary hearth furnaces and vertical shaft furnaces for the production of sponge iron.

    Get price
  • ENERGY INTEGRATION IN SPONGE IRON PLANT USING HEAT …

    ENERGY INTEGRATION IN SPONGE IRON PLANT USING HEAT …

    Sponge iron is produced primarily both by using non coking coal and natural gas as reductant and therefore classified as coal based and natural gas process respectively. Presently, there are 118 large and small sponge iron plants in India- 115 of them are coal

    Get price
  • Sponge Iron Manufacturer India

    Sponge Iron Manufacturer India

    Manufacturers Association. The Sponge Iron Manufacturers Association (SIMA) established in 1992 is an all India apex body of Indian sponge iron industry. It is the voice of the indian iron ore based sponge iron & steel industry, at both domestic and global forums. As a not-for-profit society, SIMA has been mandated to communicate the viewpoints of ...

    Get price
  • Bhagwati Sponge Private Limited

    Bhagwati Sponge Private Limited

    9 CAPITAL COST ESTIMATE BHAGWATI SPONGE PRIVATE LIMITED 1 - 1 1 – INTRODUCTION Introduction M/s. ... 3.1.1 SPONGE IRON PLANT M/s BSPL is now operating 2 DRI kilns, each of 100 TPD capacity for production of 60,000 TPA sponge ...

    Get price
  • Press Release Alaknanda Sponge Iron Ltd.

    Press Release Alaknanda Sponge Iron Ltd.

    range of 77-82% of total cost of sales and power cost remained in the range of 16-18% of total cost of sales. Major raw- materials required are sponge iron, pig iron and scrap which the company procures locally and power is sourced from

    Get price
  • Explained: What is behind rise in steel prices

    Explained: What is behind rise in steel prices

    A 8.3% increase in Sponge Iron production during the period and Scrap imports at 5.1 MT rising by 4.3% over last year have helped pencil ingot production to grow by 1.5%.

    Get price
  • Sponge iron industry needs quick actions for survival

    Sponge iron industry needs quick actions for survival

     · Limited availability of coking coal in India and abroad will encourage steel production in the country through combination of sponge iron and blast furnace, e.g sponge iron-BF-EAF route. There is tremendous scope for setting up of rotary hearth furnaces and vertical shaft furnaces for the production of sponge iron.

    Get price
  • Iron ore pellets as feed to Sponge Iron Plants

    Iron ore pellets as feed to Sponge Iron Plants

    Steelworld Iron ore pellets as feed to Sponge Iron Plants Kalluraya A S Ramachandra G K Srinivasan T M Ferro Green (India) Ltd. Pelletisation of iron ore concentrate Iron ore pelletising was firmly established in the late 40s, especially in USA, as a process of

    Get price
  • Sponge iron prices bottom out, fall 5% in January to touch …

    Sponge iron prices bottom out, fall 5% in January to touch …

    About half of India''s 80 million tonnes of annual steel production come from sponge iron route. The biggest problem with the sponge iron industry is elevated price of iron ore. Vijay Jhanwar, general secretary, CSIMA, said: "Of around 300 sponge iron producers across India, nearly half have captive iron ore supplies.

    Get price
  • DESIGN OF WASTE HEAT RECOVERY SYSTEM IN A SPONGE IRON …

    DESIGN OF WASTE HEAT RECOVERY SYSTEM IN A SPONGE IRON …

    At present, there are 118 large and small sponge iron plants operating in India, amongst them only 3 are natural gas based and the remaining 115 plants are coal based. With the availability of raw materials, high demand of sponge iron and less payback

    Get price
  • SPONGE IRON INDIA LTD

    SPONGE IRON INDIA LTD

    The Corporate Identification Number (CIN) of Sponge Iron India Ltd is U27102TG1975PLC001866. It''s authorized share capital was INR 66.00 cr and the total paid-up capital was INR 65.10 cr. The last reported AGM (Annual General Meeting) of

    Get price
  • PRESENT STATE OF THE SL / RN PROCESS AND ITS APPLICATION TO INDIAN RAW MATERIALS

    PRESENT STATE OF THE SL / RN PROCESS AND ITS APPLICATION TO INDIAN RAW MATERIALS

    the iron bearing materials. The annual produc-tions chosen are 300,000, 600,000 and 1,200,000 tons of sponge iron. The great influence of the prices of iron bearing materials and the minor influence of the capital costs on production costs of sponge iron, as

    Get price
  • Ltd

    Ltd

    Equity capital (Rs mn) 902.5 Net worth (Rs mn) -80.6 Company business Bihar Sponge Iron Ltd (BSIL) manufactures sponge iron (direct reduced iron) in its plant located at Kharsawan, Jharkhand. BSIL was incorporated in 1982 and was promoted by Bihar State ...

    Get price
  • Direct reduced iron

    Direct reduced iron

    The initial capital investment and operating costs of direct reduction plants are lower than integrated steel plants and are more suitable for developing countries where supplies of high grade coking coal are limited, but where steel scrap is generally available forIndia

    Get price
  • Cost Of Sponge Iron Plant In India

    Cost Of Sponge Iron Plant In India

    The Sponge Iron Manufacturers Association SIMA established in 1992 is an all India apex body of Indian sponge iron industry. It is the voice of the indian iron ore based sponge iron steel industry, at both domestic and global forums.

    Get price
  • Bhagwati Sponge Private Limited

    Bhagwati Sponge Private Limited

    9 CAPITAL COST ESTIMATE BHAGWATI SPONGE PRIVATE LIMITED 1 - 1 1 – INTRODUCTION Introduction M/s. ... 3.1.1 SPONGE IRON PLANT M/s BSPL is now operating 2 DRI kilns, each of 100 TPD capacity for production of 60,000 TPA sponge ...

    Get price
  • PRESENT STATE OF THE SL / RN PROCESS AND ITS APPLICATION TO INDIAN RAW MATERIALS

    PRESENT STATE OF THE SL / RN PROCESS AND ITS APPLICATION TO INDIAN RAW MATERIALS

    the iron bearing materials. The annual produc-tions chosen are 300,000, 600,000 and 1,200,000 tons of sponge iron. The great influence of the prices of iron bearing materials and the minor influence of the capital costs on production costs of sponge iron, as

    Get price
  • Sponge Iron Makers Face The Heat

    Sponge Iron Makers Face The Heat

    Sample this: India is the largest producer of sponge iron in the world with total production in the last fiscal, namely, 2006-07, being 16.27 million tonne. In the year before, that is, 2005-06 ...

    Get price
  • Ltd

    Ltd

    Equity capital (Rs mn) 902.5 Net worth (Rs mn) -80.6 Company business Bihar Sponge Iron Ltd (BSIL) manufactures sponge iron (direct reduced iron) in its plant located at Kharsawan, Jharkhand. BSIL was incorporated in 1982 and was promoted by Bihar State ...

    Get price
  • capital and operating cost of sponge iron india

    capital and operating cost of sponge iron india

    5.2.1 Capital Cost Estimation 5.2.2 Operating Cost Estimation 5.2.3 Total Annual Cost At present, there are 118 large and small sponge iron plants operating in India, amongst them only 3 are natural gas based and the remaining 115 plants are coal based.

    Get price
  • The reasons for the success of Sponge Iron Industry in …

    The reasons for the success of Sponge Iron Industry in …

    Presently, coal based units produce ~90% of the total sponge iron in India. Moreover, India''s crude steel production grew at a CAGR of 6.75% between 2006-16. The production of EAF steel as a share of total steel grew at a steady rate, from 57% (2006) to 68% (2012), thereafter, this declined to ~57% in the past four years, ending 2016.

    Get price
  • Recovery and utilization of waste heat in a coal based …

    Recovery and utilization of waste heat in a coal based …

     · It is seen that the growth of sponge iron industry in last few years is unremarkable and today India is the largest producer of sponge iron as it covers 16% of global output. According to Sponge Iron Manufacturers Association [1], India has produced around 23 million tonnes of sponge iron in the financial year of 2009–2010.

    Get price
  • Press Release RAIC Integrated Sponge & Power Private Limited …

    Press Release RAIC Integrated Sponge & Power Private Limited …

    Raw material consumption is the single largest cost component for the AIC Group (constituting about 90 % of total cost of sales). ... of West Bengal with an aggregate installed capacity of 90,000 MTPA of sponge iron, 90,000 MTPA of billets, 75,000 of TMT and ...

    Get price
  • (PDF) Design Modifications for Energy Conservation of …

    (PDF) Design Modifications for Energy Conservation of …

    sponge iron industry passes through several problems, such as lack of proper integration of heat energy, obsolete technology, and nonoptimal operation of equipment, which are making it a less

    Get price
  • Rating Rationale

    Rating Rationale

    * Susceptibility of the operating margin to volatility in raw material prices, and vulnerability to cyclicality in the infrastructure and real estate sectors: Cost of production and operating profit margin are heavily dependent on raw material prices (sponge iron and mild

    Get price
  • Sponge Iron Industry in India Gearing up to meet growing …

    Sponge Iron Industry in India Gearing up to meet growing …

    Steelworld iron plants having capacities between 15,000 to 30,000 tonnes per years. However, according to Shri N. K. Das, Director, Orissa Sponge Manufacturer''s Association as mentioned in JPC Bulletin May, 2004, there were 104 operating units in India and

    Get price
  • status of sponge iron plant, Orissa

    status of sponge iron plant, Orissa

    6 Trend of growth of sponge iron plants, Orissa 0 5 10 15 20 25 30 r e 200001020304050607 200 7-08 Year No of growth in units No of operating units A number of processes exist for the production of DRI. These may be grouped into (a) Coal-based processes and

    Get price
  • Singhal Group of Industries

    Singhal Group of Industries

    Singhal Group of Industries was formed in 2000 to meet the gap between supply and demand of Sponge Iron & Steel. The vision of the company is to achieve market leadership and prosperity in business through satisfaction of stakeholder needs by continual improvement in quality, cost and delivery of …

    Get price
  • Sponge Iron at Best Price in India

    Sponge Iron at Best Price in India

    Get Quote. Coal Based Sponge Iron ₹ 21,500/ Metric Ton. Get Quote. Sponge Iron Ask Price. We are one of the leading trading houses in the south trading in tmt bars, billets, sponge iron exports etc and specialising in HR SHEETS/ plates, We are authorised dealers …

    Get price
  • Tata Sponge Iron Limited

    Tata Sponge Iron Limited

    ensure the availability of low cost power. Operating margins increased to 22.8% in FY2018 from 11.1% in FY2017 on account of an uptrend in sponge iron realisations. However, the operating margin contracted to 16.3% in 9M FY2019 due to a rise in input costs

    Get price
  • Sponge Iron

    Sponge Iron

    Sponge Iron is fast becoming a significant input in low-cost steel production. With the availability of abundant raw material in India, the production of sponge is set to multiply over the years. Global market trends predict a steady upward movement.

    Get price
  • Sponge Iron Plant

    Sponge Iron Plant

    8923.00 Lakhs. Description: Sponge iron is the product created when iron ore is reduced to metallic iron, usually with some kind of carbon (charcoal, etc), at temperatures below the melting point of iron. This results in a spongy mass, sometimes called a bloom, consisting of a …

    Get price
  • capital and operating cost of sponge iron india

    capital and operating cost of sponge iron india

    5.2.1 Capital Cost Estimation 5.2.2 Operating Cost Estimation 5.2.3 Total Annual Cost At present, there are 118 large and small sponge iron plants operating in India, amongst them only 3 are natural gas based and the remaining 115 plants are coal based.

    Get price
  • Sponge Iron in Chhattisgarh

    Sponge Iron in Chhattisgarh

    Find Sponge Iron manufacturers, Sponge Iron suppliers, exporters, wholesalers and distributors in Chhattisgarh India - List of Sponge Iron selling companies from Chhattisgarh with catalogs, phone numbers, addresses & prices for Sponge Iron.

    Get price
  • Sponge iron industry needs quick actions for survival

    Sponge iron industry needs quick actions for survival

     · Limited availability of coking coal in India and abroad will encourage steel production in the country through combination of sponge iron and blast furnace, e.g sponge iron-BF-EAF route. There is tremendous scope for setting up of rotary hearth furnaces and vertical shaft furnaces for the production of sponge iron.

    Get price
  • Press Release Alaknanda Sponge Iron Ltd.

    Press Release Alaknanda Sponge Iron Ltd.

    range of 77-82% of total cost of sales and power cost remained in the range of 16-18% of total cost of sales. Major raw- materials required are sponge iron, pig iron and scrap which the company procures locally and power is sourced from

    Get price
  • DESIGN OF WASTE HEAT RECOVERY SYSTEM IN A SPONGE IRON …

    DESIGN OF WASTE HEAT RECOVERY SYSTEM IN A SPONGE IRON …

    At present, there are 118 large and small sponge iron plants operating in India, amongst them only 3 are natural gas based and the remaining 115 plants are coal based. With the availability of raw materials, high demand of sponge iron and less payback

    Get price
  • Iron ore pellets as feed to Sponge Iron Plants

    Iron ore pellets as feed to Sponge Iron Plants

    Steelworld Iron ore pellets as feed to Sponge Iron Plants Kalluraya A S Ramachandra G K Srinivasan T M Ferro Green (India) Ltd. Pelletisation of iron ore concentrate Iron ore pelletising was firmly established in the late 40s, especially in USA, as a process of

    Get price